Computer Simulation Model for Evaluation of Radiation and Post-Irradiation Effects in Voltage Regulator with Vertical PNP Power Transistor

Vladimir Dj. Vukić

Abstract


The aim of the presented research was to develop a faithful SPICE simulation model of radiation and post-irradiation effects in a low-dropout voltage regulator with a vertical serial PNP transistor. The main parameters for the analysis of the circuit’s radiation response were the voltage regulator’s maximum output current and the minimum dropout voltage, as well as the serial transistor’s excess base current. All the data, comprised of the old irradiation and new annealing results, were unified and normalised, in order to enable a broad insight in the radiation tolerance of the examined circuits. Initial radiation effects, as well as the late post-irradiation effects, were successfully simulated using the variations of the maximum forward emitter current gain and knee current of the serial PNP power transistor. Ten-year room temperature annealing led to a significant recovery of the serial transistor’s excess base current, yet the maximum output current and minimum dropout voltage, in most cases, expressed further degradation. On the other hand, two short-term, high-temperature annealing periods led to the tremendous recovery of all of the irradiated voltage regulators, reducing the circuit degradation down to the level perceived after absorption of nearly 10% of the total ionising dose.

Keywords


vertical PNP transistor; excess base current; forward emitter current gain; computer simulation; voltage regulator; ionising radiation.

Full Text:

PDF

References


G.A. Rincon-Mora, Analog IC design with low-dropout regulators, McGrawHill Education (2014).

R.L. Pease, Total ionizing dose effects in bipolar devices and circuits, IEEE T Nucl Sci 50 (2003) 539-551.

D.M. Fleetwood, Total ionizing dose effects in MOS and low-dose-rate-sensitive linear-bipolar devices, IEEE T Nucl Sci 60 (2013) 1706-1730.

V.S. Pershenkov, V.B. Maslov, S.V. Cherepko, I.N. Shvetzov-Shilovsky, V.V. Belyakov, A.V. sogoyan, V.I. Rusanovsky, V.N. Ulimov, V.V. Emelyanov, V.S. Nasibullin, The effect of emitter junction bias on the low dose-rate radiation response of bipolar devices, IEEE T Nucl Sci 44 (1997) 1840–1848.

J. Assaf, Bulk and surface damages in complementary bipolar junction transistors produced by high dose irradiation, Chin Phys B 27 (2018) 016103 1-8.

F.J. Franco, C. Palomar, J.G. Izquierdo, J.A. Agapito, SPICE simulations of single event transients in bipolar analog integrated circuits using public information and free opeen source tools, IEEE T Nucl Sci 62 (2015) 1625-1633.

M.R. Shaneyfelt, J.R. Schwank, D.M. Fleetwood, R.L. Pease, J.A. Felix, P.E. Dodd, M.C. Maher, Annealing behaviour of linear bipolar devices with enhanced low-dose-rate sensitivity, IEEE T Nucl Sci 51 (2004) 3172-3177.

J. Beaucour, T. Carribre, A. Gach, P. Poirot, Total dose effects on negative voltage regulator. IEEE T Nucl Sci 41 (1994) 2420-2426.

P. C. Adell, R. D. Schrimpf, W. T. Holman, J. L. Todd, S. Caveriviere, R. R. Cizmarik, K. F. Galloway, Total dose effects in a linear voltage regulator, IEEE T Nucl Sci 51 (2004) 3816-3821.

V. Ramachandran, B. Narasimham, D.M. Fleetwood, R.D. Schrimpf, W.T. Holman, A.F. Witulski, R.L. Pease, G.W. Dunham, J.E. Seiler, D.G. Platteter, Modeling total-dose effects for a low-dropout voltage regulator, IEEE T Nucl Sci 53 (2006) 3223-3231.

R.L. Pease, S. McClure, J. Gorelick, S.C. Witczak, Enhanced low-dose-rate sensitivity of a low-dropout voltage regulator, IEEE T Nucl Sci 45 (1998) 2571-2576.

E. W. Enlow, R. L. Pease, W. E. Combs, R. D. Schrimpf, R. N. Nowlin, Response of advanced bipolar processes to ionizing radiation, IEEE T Nucl Sci 38 (1991) 1342-1349.

R.L. Pease, ELDRS in bipolar linear circuits: a review, IEEE T Nucl Sci 56 (2009) 1894-1908.

A. Holmes-Siedle, L. Adams, Handbook of Radiation Effects, Oxford University Press (2004).

L4940 Series - very low dropout 1.5A regulators, STMicroelectronics (2003).

F. Bertotti, C. Cini, C. Contiero, P. Galbiati, Monolithically integrated semiconductor device containing bipolar junction transistors, CMOS and DMOS transistors and low leakage diodes and a method for its fabrication, United States Patent 4887142, Dec. 12 (1989).

V. Vukić, P. Osmokrović, Total ionizing dose response of commercial process for synthesis of linear bipolar integrated circuits, J Optoel Adv Mater 8 (2006) 1538-1544.

V. Vukić, P. Osmokrović, Impact of forward emitter current gain and geometry of PNP power transistors on radiation tolerance of voltage regulators, Nucl Technol Radiat 25 (2010) 179-185.

V.Dj. Vukić, P.V. Osmokrović, On-line monitoring of base current and forward emitter current gain of voltage regulator’s serial PNP transistor in radiation environment, Nucl Technol Radiat 27 (2012) 152-164.

V.Dj. Vukić, P.V. Osmokrović, Gamma-radiation response of isolated collector vertical PNP power transistor in moderately loaded voltage regulator L4940V5, J Optoel Adv Mater 15 (2013) 1075-1083.

V.Dj. Vukić, P.V. Osmokrović, Impact of the excess base current and the emitter injection efficiency on radiation tolerance of a vertical PNP power transistor in a voltage regulator, Inf MIDEM 43 (2013) 27-40.

G.C. Messenger, M.S. Ash, The Effects of Radiation on Electronic Systems, Van Nostrand Reinhold (1992).

C.E. Barnes, D.M. Fleetwood, D.C. Shaw, P.S. Winokur, Post irradiation effects (PIE) in integrated circuits, IEEE T Nucl Sci 39 (1992) 328-341.

R. Gariboldi, M. Morelli, Very-low-drop voltage regulator with a fully complementary power process, IEEE J Solid-St Circ 22 (1987) 447–450.

A. Andreini, C. Contiero, P. Galbiaty, A new integrated silicon gate echnology combining bipolar linear, CMOS logic, and DMOS power parts, IEEE T Electr Dev 33 (1986) 2025-2030.

F. Bertotti, P. Ferrari, M.T. Gatti, Saturation limiting system for a vertical, isolated collector PNP transistor and monolithically integrated structure thereoff, United States Patent 4887141, Dec. 12 (1989).

LTSpice-Version 4.13q, Linear Technology Corporation (2012).

V.Dj. Vukić, Rapid and long-term gamma-radiation annealing in low-dropout voltage regulators, Nucl Technol Radiat 32 (2017) 155-165.

V.Dj. Vukić, P.V. Osmokrović, Failure of the negative voltage regulator in medium-photon-energy X radiation field, Microelectron Reliab 54 (2014) 79-89.

Standard.BJT, LT Wiki, Linear Technology Corporation (2012) http://ltwiki.org/?title=standard.bjt

BC808-25LT1G, General Purpose Transistors, OnSemiconductor (2016).

D.M. Schmidt, D.M. Fleetwood, R.D. Schrimpf, R.L. Pease, R.J. Graves, G.H. Johnson, K.E. Galloway, W.E. Combs, Comparison of ionizing-radiation-induced gain degradation in lateral, substrate and vertical PNP BJTs, IEEE T Nucl Sci 42 (1995) 1541-1549.

D.M. Schmidt, A. Wu, R.D. Schrimpf, D.M. Fleetwood, R.L. Pease, Modeling ionizing radiation induced gain degradation of the lateral PNP bipolar junction transistor, IEEE T Nucl Sci 43 (1996) 3032-3039.

A. Wu, R.D. Schrimpf, H.J. Barnaby, D.M. Fleetwood, R.L. Pease, S.L. Kosier, Radiation-Induced Gain Degradation in Lateral PNP BJTs with Lightly and Heavily Doped Emitters, IEEE T Nucl Sci 44 (1997) 1914-1921.

A.H. Johnston, B.G. Rax, Testing and qualifying linear integrated circuits for radiation degradation in space, IEEE T Nucl Sci 53 (2006) 1779-1786.

Star-HSPICE Manual, Avant! Corporation (1998).

H.J. Barnaby, B. Vermeire, M.J. Campola, Improved model for inncreased surface recombination current in irradiated bipolar junction transistors, IEEE T Nucl Sci 62 (2015) 1658-1664.

X. Li, J. Yang, H.J. Barnaby, K.F. Galloway, R.D. Schrimpf, D.M. Fleetwood, C. Liu, Dependence of ideality factor in lateral PNP transistors on surface carrier concentration, IEEE T Nucl Sci 64 (2017) 1549-1553.

A. Johnston, R. Swimm, R.D. Harris, D. Thorbourn, Dose rate effects in linear bipolar transistors, IEEE T Nucl Sci 58 (2011) 2816-2823.


Refbacks

  • There are currently no refbacks.


Copyright (c) 2018 Informacije MIDEM